台达标准10000-016216-ENG(4)

DELTA ELECTRONICS, INC.THESE DRAWINGS AND SPECIFICATIONS ARE THE PROPERTY OF DELTA ELECTRONICS, INC. AND SHALL NOT BE REPRODUCED OR USED AS THE BASIS FOR THE MANUFACTURE OR SELL OF APPARATUSES OR DEVICES WITHOUT PERMISSION.

DESCRIPTION: MANAGEMENT STANDARDS FOR ENVIRONMENT-RELATED SUBSTANCES DRAWING NO.: REV.

10000-0162SHEET9

16TO49

台达标准

- Lead oxide in plasma display panels and surface conduction electron emitter displays used in structural elements, notably in the front and rear glass dielectric layer, the bus electrode, the black stripe, the address electrode, the barrier ribs, the seal frit and frit ring, and in print pastes. However, the leaded solder and lead which are used for plastics (including rubber), paints, and inks and which are classified at Level 1 are subject to the corresponding regulations. - Allowable concentration of lead as an additive in the following alloys: Type of alloy Allowable content of lead Steel Less than 0.35 wt% Aluminum Less than 0.4 wt% Copper alloy(including brass and Less than 4 wt% phosphor bronze) Solder Less than 800 ppm Allowable concentration: 1. Less than 50 ppm for plastics, rubbers, paints and inks. 2. Less than 800 ppm for other homogeneous materials if not be regulated in this specification. Standards for measurement: 1). Pre-conditioning * 1. An acid decomposition method under the existence of sulfuric acid or hydrogen-peroxide water (EPA 3050B) 2. A pressurized acid decomposition method done in a sealed container (EPA 3052:1996). * If precipitates (insoluble matter) are produced, dissolve them totally by taking some means (e.g. alkali dissolution). 2). Measurement methods Typical measurement methods are as follows: 1. Inductively Coupled-Plasma-Atomic (Optical) Emission Spectroscopy (ICP-AES, ICP-OES) (e.g. EN ISO 11885:1998) 2. Atomic Absorption Spectroscopy (AAS) (e.g. EN ISO5961:1995) 3. Inductively Coupled-Plasma Mass Spectroscopy (ICP-MS) 3). Other measurement methods can be accept

ed if they are referred to latest version of IEC 62321 (IEC 111) corresponding section. Any one of the measurement methods above (except AAS) enables you to analyze cadmium and lead simultaneously. Note: Delta will not accept any other pre-conditioning method unless it is with specific approval. (e.g. EN-71, In-house)

DELTA ELECTRONICS, INC.THESE DRAWINGS AND SPECIFICATIONS ARE THE PROPERTY OF DELTA ELECTRONICS, INC. AND SHALL NOT BE REPRODUCED OR USED AS THE BASIS FOR THE MANUFACTURE OR SELL OF APPARATUSES OR DEVICES WITHOUT PERMISSION.

DESCRIPTION: MANAGEMENT STANDARDS FOR ENVIRONMENT-RELATED SUBSTANCES DRAWING NO.: REV.

10000-0162SHEET10

16TO49

台达标准

* ExamplesMaterial Lead; metal Lead/ Tin alloy Lead (II) oxide Lead (IV) oxide Dilead trioxide Trilead tetraoxide; lead (II, IV) oxide Lead azide Lead (II) fluoride Lead (II) chloride Lead (IV) chloride; lead tetrachloride Lead (II) iodide Lead (II) sulfide Lead (II) cyanide Lead fluoroborate Lead fluosilicate Lead nitrate Lead carbonate Lead hydroxycarbonate Lead perchlorate Lead (II) sulfate Lead oxide sulfate Lead (II) phosphate Lead thiocyanate Lead (II) acetate, tryhydrate Lead (II) acetate Lead (IV) acetate Lead oleate Lead stearate Lead (II) metaborate Lead metasilicate Lead antimonite Lead arsenate (1:1) Lead (II) arsenate CAS No. 7439-92-1 39412-44-7 1317-36-8 1309-60-0 1314-41-6 13424-46-9 7783-46-2 7758-95-4 13463-30-4 10101-63-0 1314-87-0 592-05-2 13814-96-5 25808-74-6 10099-74-8 598-63-0 1344-36-1 13637-76-8 7446-14-2; 15739-80-7 12202-17-4 7446-27-2 592-87-0 6080-56-4 301-04-2 546-67-8 1120-46-3 7428-48-0 10214-39-8 11120-22-2; 22569-74-0 122666-38-5; 13150-89-9 7784-40-9 10031-13-7 Chemical formulas Pb Pb-Sn PbO PbO2 Pb2O3 Pb3O4 PbN6 PbF2 PbCl2 PbCl4 PbI2 PbS Pb(CN)2 Pb(BF4)2 PbSiF6 Pb(NO3)2 PbCO3 (PbCO3)2Pb(OH)2 Pb(ClO4)2 PbSO4 Main purposes Solder, Brazing materials, and electrical connection Pigments, coloring agents, rubber vulcanization accelerators, and solid lubricants Lead-acid batteries, rubber curing agents, and materials for pigments Materials for chemical synthesis Pigments, lead-acid batteries, glass, and paints Detonators Special optical glass, pigments Reagents, materials for chemical synthesis Reagents Bronze, printing, photographs, and medicinal purposes Infrared ray detectors, semiconductors Antirust pigments Plating, anticorrosive surface treatment Plating, lead refinement Optical glass, materials for chemical synthesis Reagents Pigments, vinyl chloride stabilizers Chemicals Pigments, rubber compounding ingredients, vinyl chloride stabilizers, and batteries Pigments Stabilizers for plastics Stain, matches Materials for chemical synthesis Materials for chemical synthesis Materials for chemical synthesis

Pb4SO7 Pb3(PO4)2 Pb(SCN)2 Pb(CH3COO)2 3H2O Pb(CH3COO)2 Pb(CH3COO)4 Pb[CH3(CH2)7CH=CH(CH2) Lubricants, curing agents, etc. 7COO]2 Lubricants, stabilizers for vinyl Pb(C17H35COO)2 chloride Desiccants for paints Pb(BO2)2H2O PbSiO3 Pb3(SbO4)2 PbHAsO4 Pb(AsO2

)2 Manufacture of ceramics Pigments, coloring agents for glass Fertilizers Pesticides

DELTA ELECTRONICS, INC.THESE DRAWINGS AND SPECIFICATIONS ARE THE PROPERTY OF DELTA ELECTRONICS, INC. AND SHALL NOT BE REPRODUCED OR USED AS THE BASIS FOR THE MANUFACTURE OR SELL OF APPARATUSES OR DEVICES WITHOUT PERMISSION.

DESCRIPTION: MANAGEMENT STANDARDS FOR ENVIRONMENT-RELATED SUBSTANCES DRAWING NO.: REV.

10000-0162SHEET11

16TO49

台达标准

Lead chromate; chrome yellow Lead molybdate Calcium plumbate Tetramethyl lead Tetraethyl lead Lead hydrocarbonate Lead selenide Other lead compounds

1344-37-2 10190-55-3 12013-69-3 75-74-1 78-00-2 1319-46-6 12069-00-0

PbCrO4 PbMoO4 Ca2PbO4 Pb(CH3)4 Pb(C2H5)4 C2H2O8Pb3 PbSe

Pigments, paints, and inks Pigments, reagents Oxidizers, fireworks, and matches Additives for gasoline Additives for gasoline

DELTA ELECTRONICS, INC.THESE DR …… 此处隐藏：6294字，全部文档内容请下载后查看。喜欢就下载吧 ……